[morn]

Dear Forum,

I have a huge problem with my GSXR '95. The problem is that sometimes, the revolution counter goes crazy, and RPM goes up and down between 1000-4000, and it stalls and the exhaust pipe fires, and then it drives on. But some other times it just, goes directly to 0, and then the engine dies. And then normally I can just turn it on, and drive on.. When I drive on the freeway (about 110-130 km/h), the problem never occurs., but when i drives around in the city with 50 km/h and lover, the problem will sometime occur….
I have tried another engine (but the same carburetor), all the wiring have been checked, new sparks etc.

Anyone have any ideas?? :hmmm:

 

[ClevelandWheeler]

Dear Forum,

I have a huge problem with my GSXR '95. The problem is that sometimes, the revolution counter goes crazy, and RPM goes up and down between 1000-4000, and it stalls and the exhaust pipe fires, and then it drives on. But some other times it just, goes directly to 0, and then the engine dies. And then normally I can just turn it on, and drive on.. When I drive on the freeway (about 110-130 km/h), the problem never occurs., but when i drives around in the city with 50 km/h and lover, the problem will sometime occur….
I have tried another engine (but the same carburetor), all the wiring have been checked, new sparks etc.

Anyone have any ideas?? :hmmm:

does it do it while the clutch is engaged, thinking it might be your clutch going bad and slipping at low speeds.

 

[morn]

does it do it while the clutch is engaged, thinking it might be your clutch going bad and slipping at low speeds.

No, im just riding the bike normal, and now it happens all the time, last night it worked for about 2-3 km, and then it just started losing gas, and started firing from the exhaust, and then it died... Then I could start it agian, and drive for 2-3 km, and then it did it again... But some times it wont start, it is just total death, the starter dosent even react, but if I wait 30 sec, it would react and start the bike.

 

[Streetdremz]

Your pilot jet is clogged.

Pull the carb and clean it out. Pilot jet is what feeds low volume of fuel (idle and low revs). If your fine doing high speeds your main jet is clear.